Volvo All Engines (2004 Emissions) Fault Code: PID 111 FMI 3 Coolant Level Switch
Fault Condition: This fault will become active when the EMS Module detects that the coolant level switch has experienced a power loss or that the level can not be detected. Engine power may be derated.
Possible repairs:
Turn the ignition key OFF first.
1) Disconnect the Coolant Level Switch connector. With the coolant filled to the proper level, check for continuity across the two terminals of the Coolant Level Switch. If continuity does not exists, replace the Coolant Level Switch and retest the system.
2) Disconnect EMS Module connector B and the Coolant Level Switch connector. Measure for continuity between EMS Module connector B pin 10 and pin 2 of the Coolant Level Switch connector. If there is NO continuity, repair the open in the harness reference voltage line.
3) Disconnect EMS Module connector B and the Coolant Level Switch connector. Measure for continuity between EMS Module connector B pin 23 and pin 1 of the Coolant Level Switch connector. If there is NO continuity, repair the open in the harness reference voltage line.
4) Disconnect the Coolant Level Switch connector. Disconnect EMS Module connector B. Measure for voltage between Coolant Level Switch pin 1 and a good ground. If measured voltage is NOT approximately 0 volts, locate and repair the short to power in the harness.
5) Disconnect the Coolant Level Switch connector. Disconnect EMS Module connector B. Check for continuity between Coolant Level Switch pin 1 and a good ground. If continuity exists, locate and repair the short to ground in the harness.
6) Reconnect the connectors to the Coolant Level Switch. Reconnect EMS Module connectors A and B. Turn the ignition key ON and check for any fault codes. If PID 111 is still active, check EMS Module connector A and B for dirt, shorted or corroded pins, or any other repairable damage. If no problems are evident, or are not repairable, replace the EMS Module and retest the system.
Related
-
Wabco ToolBox plus 13.7.0.1 + ECAS CAN2 v3.00 Diagnostics Software
Trucks software $84.00Rated 0 out of 5
-
premium volvo tech tool update 2.8.150 diagnostic software 1pc
Trucks software $150.00Rated 0 out of 5 -
DOWNLOAD NISSAN UD DIESEL PC-CONSULT DIAGNOSTIC 1.1.13 & PC-REPROMASTER 1.2.0
NISSAN UD $100.00Rated 0 out of 5 -
JPRO 2022 v1 Commercial Vehicle Diagnostics V1 Software Download & Installation Service ( 1 PC )
JPRO $94.00Rated 0 out of 5 -
VOLVO PREMIUM TECH TOOL PTT 2.7.116 + APCI 2021 + devtool ( ONLINE )
Trucks software $80.00Rated 0 out of 5 -
Volvo Premium Tech Tool PTT 2.8.130 Diagnostic Software 04.2022 ACPI ( 1 PC )
Trucks software $143.00Rated 0 out of 5
Related products
-
Allison 1000 & 2000 Gen 4 Fault Codes: P0873 Transmission Pressure Switch Solenoid E Circuit High
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P0876 Transmission Reverse Pressure Switch Circuit Stuck Open
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P1688 Unmanaged Engine Torque Delivered To TCM Signal
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P2771 Four-Wheel Drive Switch Circuit
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: U1301 J1850 (Class 2) Serial Data Communication Link Low
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P0875 Transmission Reverse Pressure Switch Circuit Malfunction
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: U1016 Class 2 J1850 (Class 2) Powertrain Controller State of Health Failure
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P0871 Transmission Pressure Switch Solenoid E Circuit Stuck Open
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: U0073 CAN Bus Reset Counter Overrun
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: U1000 Class 2 Loss of Serial Data Communication
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: U1064 J1850 (Class 2) TBC Controller State of Health Failure
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P1892 Throttle Position Sensor Pulse Width Modulation (PWM) Signal High Input
1000 & 2000 Gen 4 $50.00Rated 0 out of 5 -
Allison 1000 & 2000 Gen 4 Fault Codes: P0870 Transmission Pressure Switch Solenoid E Circuit
1000 & 2000 Gen 4 $50.00Rated 0 out of 5
-
SERVICE MANUAL 3000 AND 4000 SERIES GEN 4 GENERATION – ALLISON
Allison$19.00Original price was: $19.00.$17.00Current price is: $17.00.Rated 0 out of 5