PACCAR MX (2004 Emissions) Fault Code: P0269 Cylinder 3 – Torque Contribution Too Low
PACCAR MX (2004 Emissions) Fault Code: P0269 Cylinder 3 – Torque Contribution Too Low
SET CONDITIONS:
The PCI ECU (D420) detects that the combustion contribution of cylinder 3 is lower relative to the other cylinders.
DIAGNOSTIC CONDITION:
This diagnostic runs when the engine is running at a steady speed and load, and the vehicle speed is steady.
CORRESPONDING OBD READINESS MONITOR:
Fuel system monitor
RESET CONDITION:
This DTC changes to inactive when the fault is no longer detected.
REPAIR VERIFICATION:
1. Clear all DTCs.
2. Test drive or operate the vehicle to meet the following conditions:
– Corresponding readiness monitor displays ‘Ready’
– Diagnostic conditions are met
– Set conditions are met
3. Did the DTC come back? (Can be pending, inactive or active)
– No, repair successful
– Yes, repair unsuccessful
POSSIBLE CAUSES:
1. Faulty cylinder 3 injector (under-fueling)
2. Faulty MX Engine Brake cylinder 3
3. Symptom: Slightly reduced power:
– Incorrect valve clearance
– Major imbalance in the drive shaft
4. Symptom: Engine block vibration at high load, damaged flywheel
5. Mechanical defect (for example damaged cam follower or broken valve)
ADDITIONAL INFORMATION:
1. The PCI ECU can detect and identify the cylinder contribution of every cylinder based on analysis of the rotational speed of the crankshaft using a:
– Cylinder-to-cylinder engine speed comparison, and
– Cylinder-to-cylinder rotational crankshaft acceleration comparison
2. This DTC can be the result of another DTC that indicates too high of a combustion contribution of another cylinder.
Related
-
JPRO 2022 v1 Commercial Vehicle Diagnostics V1 Software Download & Installation Service ( 1 PC )
JPRO $94.00Rated 0 out of 5 -
ddct Detroit diesel calibration tool (DDCT) v4.5 English Include Calibrations & Metafiles
Detroit $30.00Rated 0 out of 5 -
CAT ET 2021A (Caterpillar Electronic Technician) + Factory Password (1 PC )
CAT $65.00Rated 0 out of 5 -
Volvo Impact 2021 Trucks & Buses 06.2021 DVD 9116 Spare Parts Catalog
Trucks software $55.00Rated 0 out of 5
Related products
-
SERVICE MANUAL DETROIT DIESEL DDEC III-IV Single ECM Troubleshooting Guide
DETROIT $48.00Rated 0 out of 5